Buy (625 RUB)
|Generate QR code
Open Access
Subscription or Fee Access
Implementation of Environmentally Sound Method of Removal of Insoluble Deposition in Boilers
https://doi.org/10.18412/1816-0395-2017-8-33-37
Abstract
There was considered chemistry and offered environmentally sound safe way of chemical cleaning and removal of insoluble thermally and chemically resistant deposits, which are formed in steam boilers (on the sample of boilers of small and medium pressure). On the base of X-ray and radiographic analysis of these deposits was established their phase and elemental composition, substantiated conditions of its dissolution and decomposition. There were conducted experimental research of dissolution dynamic of insoluble components of deposits – wollastonite, diopside, tremolite, calcium hydroxyapatite and carbonate calcium and magnesium by prepared water after sodium cycle with addition complexon (Trilon B) and reagent HydroGhem 160.
About the Authors
Z.A. Temerdashev
Kuban State University
Russian Federation
Dr Sci. (Chem.), Professor
Russian Federation
Dr Sci. (Chem.), Professor
A.M. Vasilyev
Kuban State University
Russian Federation
Cand. Sci. (Chem.)
Russian Federation
Cand. Sci. (Chem.)
L.V. Vasilyeva
Kuban State University
Russian Federation
Engineer-researcher
Russian Federation
Engineer-researcher
References
1. Балабан-Ирменин Ю.В., Богловский А.В., Васина Л.Г., Рубашов А.М. Закономерности накипеобразования в водогрейном оборудовании систем теплоснабжения (обзор). Энергосбережение и водоподготовка. 2004. №3(30). С. 10—16.
2. Нерезько А.В., Карницкий Н.Б., Чиж В.А. Теплофизические свойства и структура отложений на поверхности нагрева энергетического оборудования. Известия высших учебных заведений и энергетических объединений СНГ. Энергетика. 2007. № 1. С. 55—60.
3. Моргулова Т.Х. Химические очистки теплоэнергетического оборудования: М., Энергия, 1978. 178 с.
4. Темердашев З.А., Васильев А.М., Васильева Л.В. Зависимость химического состава отложений в паровых котлах от качества природной воды. Экология и промышленность России. 2017. Т. 8. № 4. С. 54—58.
5. Alireza B., Hari B.V. Prediction of silica carry-over and solubility in steam of boilers using simple correlation. Applied Thermal Engineering. 2010. V.30. P. 250—253.
6. Bin Dong, Ying Xu, Shengjian Jiang, Xiaohu Dai. Effect of reusing the advanced-softened, silica-rich, oilfield-produced water (ASOW) on finned tubes in steam-injection boiler. Desalination. 2015. V. 372. P. 17—25.
7. Uibual M., Kuusika R., Andreasb L., Kirsimдe K. The CO2-binding by Ca-Mg-silicates in direct aqueous carbonation of oil shale ash and steel slag. Energy Procedia. 2011. V. 4. P. 925—932.
8. Xu T., Apps J.A., Pruess K. Numerical simulation of CO2 disposal by mineral trapping in deep aquifers. Appl. Geochem. 2004. V. 19. P. 917—936.
9. Luнs M.C.Pereira, Antonin Chapoy, Rod Burgass, Mariana B. Oliveira, Joгo A.P. Coutinho, Bahman Tohidi. Study of the impact of high temperatures and pressures on the equilibrium densities and interfacial tension of the carbon dioxide / water system. The Journal of Chemical Thermodynamics. 2016. V. 93. P. 404—415.
10. Гусева О.В., Ковалева Н.Е. Коррекционные водно-химические режимы паровых котлов с использованием марки Аминат. Энергосбережение и водоподготовка. 2007. № 6(50). С. 17—19.
11. Лурье Ю.Ю. Справочник по аналитической химии. М., Химия, 1989. 448 с.
Review
For citations:
Temerdashev Z., Vasilyev A., Vasilyeva L. Implementation of Environmentally Sound Method of Removal of Insoluble Deposition in Boilers. Ecology and Industry of Russia. 2017;21(8):33-37. (In Russ.) https://doi.org/10.18412/1816-0395-2017-8-33-37
Views:
549
Email this article 